Matthys P. Levy
buildings
FORENSIC ENGINEERING
Study Absolves Twin Tower Trusses, Fireproofing 11/04/02
By Nadine M. Post
The most comprehensive study yet on the destruction of the
"There is no doubt left about the sequence of failure," says Matthys P. Levy, chairman of Weidlinger Associates Inc., the New York City-based engineer that led the study.
"Failure of the floors...was shown not to have had any significant role in the initiation of the collapses," says the report. Levy describes the floor truss system as "not unsubstantial," acting more like a membrane than a one-way system. "There was nothing wrong with it," he says. If the floor trusses had collapsed first, there would have been a mass of smoke as opposed to differentiated smoke, floor by floor, he adds.
IMPACT SEQUENCE | |
 |  |
| ONE WTC | TWO WTC |
| HITS Planes caused different damage (Graphics courtesy of Weidlinger Associates Inc.) | |
The report also exonerates the steel's sprayed-on fireproofing. Computer models that identify the columns affected by the planes' impacts and flying debris confirm that columns with intact fireproofing did not succumb to the jet- fuel-triggered fire. The report also says, of the fireproofing knocked off the steel, that "no fireproofing is designed to withstand such devastating impacts."
Levy echoes preliminary reports. "The buildings were well-designed, rugged and withstood a tremendous impact," he says. "The fact that they did not collapse on the planes' impacts saved tens of thousands of lives."
Questions brought into the limelight by Sept. 11 include whether there is a better way to fight fires in tall buildings, says the engineer. "It's always been a problem," says Levy.
Another issue is whether less-frangible fireproofing should be considered for steel structures considered vulnerable to blasts and attacks. Experts might also reconsider location of fire stairs and the strengthening of the core, says Levy. But he cautions, "You can never anticipate exactly what the threat is going to be."
Regarding building materials, Levy says: "Concrete is not foolproof either."
The Weidlinger-led study was commissioned by Silverstein Properties Inc., the New York City-based leaseholder of the
Silverstein's insurers claim the collapse of the south tower, Two WTC, rendered the north tower, One WTC, unsalvageable even before it collapsed. If they prevail, Silverstein would receive only $3.5 billion (ENR 10/7 p. 11). Click here to view one WTC collapse sequence
The insurers commissioned their own engineering study, written by Exponent Failure Analysis Associates Inc.,
In the Silverstein study, engineers put forth similar but not exact failure scenarios for both towers: The planes and flying debris hobbled the buildings at the zones of impact. Intact columns, their fireproofing knocked off by flying debris, ultimately lost strength and failed in the fuel-triggered fire.
Though hit by the second plane later than One WTC, Two WTC fell first, "primarily" because the plane struck it off-center and at an angle and caused damage that compromised the southeast corner of the core. "This confirms an earlier theory," says Levy. Click here to view two WTC collapse sequence
At each tower, exterior wall and core columns, connected by a steel "hat truss" at the building's top, initially redistributed loads away from the damaged areas to remaining columns. In Two WTC, the hat truss eventually could not deal with the situation of the corner columns gone, says Levy.
The team determined that the initial hits destroyed 33 of 59 perimeter columns in the north face of One WTC and 29 of 59 perimeter columns in the south face of Two WTC. Computer analysis showed that the impact of the planes also destroyed or disabled some 20 of 47 columns in the center of the core of One WTC and some five of 47 columns in the southeast corner of the core of Two WTC.
The Silverstein findings are based on analysis of original structural drawings, thousands of photos and dozens of videos. The team used computer modeling, including a program called FLEX developed by Weidlinger for the Dept. of Defense, and fire evaluation techniques to simulate the condition of each tower at critical times, creating impact and collapse sequences.
The National Institute of Standards and Technology, which recently began a two-year technical study on the World Trade Center disaster, is using both team's studies to perform a "very systematic" analysis, says S. Shyam Sunder, chief of NIST's materials and construction research division, Gaithersburg, Md. "The real question is whether there was one dominant failure mechanism or a combination," he adds.
